Pro-link Extra Duty Bowl Cleaner B14097 Manuel d'utilisateur télécharger pdf

BRU MATERIAL SAFETY DATA SHEET N/A=Not Applicable

Prepared by: Regulatory Affairs Dept. (Prepared According to 29 CFR 1910.1200) Effective Date: 10/08 Revision: 5/12

SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION

Supplier Name:

Misco Products Corporation

Supplier’s Address:

1048 Stinson Drive Reading, PA 19605

Supplier’s Phone #: (610) 926-4106

Product Name: Brute

Generic Name: High Acid Emulsion Bowl Cleaner

Chemical Family: Hydrochloric Acid/Detergent Blend

Formula: Proprietary

Distributor’s Name:

Distributor’s Address:

Distributor’s Phone #:

SECTION 2-INGREDIENT INFORMATION

CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV

Water 7732-18-5 to 100

Hydrochloric Acid 7647-01-0 24 min 5 ppm 5 ppm N/A

Lauramine Oxide 1643-20-5 0 to 5

Benzalkonium Chloride 68424-85-1 0 to 5

Alcohols, C12-C15, Ethoxylated 68131-39-5 0 to 5

SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA

Boiling Point (°F): 205 F. Specific Gravity: 1.175

Vapor Pressure: 33mm Hg @ 68 F. Vapor Density (Air=1): >1

% Volatile: 90+ pH: 0.5-1.0

Solubility in Water: Complete Evaporation Rate (Water=1): <1

Physical Description: Thin white opaque liquid with characteristic pungent odor.

Flash Point (Method Used): N/A

Upper Explosion Limit: N/A Lower Explosion Limit: N/A

Extinguishing Media: N/A

Special Firefighting Procedures: Non Flammable

Unusual Fire and Explosion Hazards: N/A

SECTION 5-REACTIVITY DATA

Stability: Stable Hazardous Polymerization: None

Hazards Decomposition Products: Hydrogen gas formed on contact with metals. HCL

vapors emitted when heated. Chlorine gas may form by electrolysis or oxidation.

Incompatibility (Materials to Avoid): Corrosive to many materials. Strong alkalis or

oxidizers, bleaching agents, amines and carbonates. Contact with metals, metal oxides,

soft metals and iron may generate hydrogen gas.

SECTION 6-STORAGE AND HANDLING INFORMATION

DANGER! POISON. ACID Corrosive. Causes chemical burns to eyes and skin. Harmful if inhaled. Harmful if swallowed. Avoid contact with eyes, skin and clothing. Avoid

breathing of vapors. Wear rubber gloves and protective eyewear when handling. Keep out of reach of children. For use by trained personnel only. Do not mix with alkali cleaners,

oxidizers or other cleaning products. Keep container closed during storage. For institutional and industrial use only. Wash hands after each use. Use in well-ventilated area only.

Avoid contact with aluminum, brass, iron and strong alkaline cleaners or bleaches

SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION

Effects of Overexposure:

Skin: Severe skin irritant. Prolonged or repeated contact will cause permanent chemical

burns.

Eyes: Severe eye irritant. Liquid and mists will burn or injure eyes, causing permanent

corneal damage.

Inhalation: Strong irritant to mucous membranes of the nose, throat, and lungs. Vapors

may cause choking, burning sensation of throat and lungs, leading to irreversible

damage. May be fatal. Chronic exposure may damage teeth.

Ingestion: POISON Irritating and corrosive to the mouth and throat on immediate

contact. May be fatal. Cause severe ulceration of mucous membranes.

Respiratory Protection: NIOSH approved acid-gas air purifying canister when used in

confines or poorly ventilated areas

Ventilation Requirements: Provide mechanical exhaust to keep TLV of Section 2

ingredient (Hydrochloric Acid) below acceptable limit.

Protective Gloves: Full arm length acid proof, rubber, or neoprene.

Eye Protection: Chemical splash goggles or full-face safety shield.

Other Protective Equipment: Eyewash station should be made available near site

where used. Chemical resistant apron should be worn when danger of splash contact

will occur.

First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES

Skin: Immediately remove contaminated clothing. Flush exposed area with large

quantities of water followed by washing with mild soap. Seek medical attention

immediately.

Eyes: Immediately flush with large quantities of water for at least 15 minutes, holding

eyelids open. Seek medical attention immediately.

Inhalation: Get to fresh air. Seek medical attention immediately.

Ingestion: Do not induce vomiting. Drink large quantities of water. Seek medical

attention immediately.

Steps to be taken in Case Material is Released or Spilled: Immediately evacuate all

unessential personnel from area. Ventilate area well. Acquire special protection

equipment as noted in Section 8. Absorb spill with inert material. Neutralize with soda

ash or lime. Avoid discharge to sewer or open waterways.

Waste Disposal Method: Any method in accordance with local, state and federal laws.

Best method is to recycle or reuse for intended purpose. If disposed of in its purchased

form, this product has the RCRA characteristic of corrosivity and would have an EPA

Hazardous waste number of D002. Consult local authorities for disposal in public sewer.

Do not

dispose of into storm drain, stream, river or to ground. Rinse container

thoroughly before discarding in trash.

SECTION 10-REGULATORY INFORMATION

SARA Title III - Section 311/312 -Hazard Categories: Shipping Information:

HMIS Hazardous Materials

No - Fire Hazard FOR CONTAINERS > 1 Liter: UN1760, Corrosive liquids, n.o.s.

Identification System

No - Sudden Release of Pressure Hazard (contains Hydrochloric Acid), 8, PG II

Health 3

No - Reactivity Hazard FOR CONTAINERS ≤ 1 Liter: LTD QTY

Flammability 0

Yes - Immediate (acute) Health Hazard

Reactivity 0

No - Delayed (chronic) Health Hazard

Personal Protection C

FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)

This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act of 1986 and

of 40 CFR 372.

CAS# Chemical Name Percent by Weight

Exempt None

This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.

CAS# Chemical Name Percent by Weight

None

SECTION 11-OTHER INFORMATION

This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the application of this

information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to provide a safe workplace, using the

health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from the improper handling and use of this product

REVISION: 3/16/12- Revised Sec. 10 Shipping Information 5/14/12-Revised Sec 10 Shipping under 1 gal. descriptor. Changed ingredient info. in Sec. 2; Descrip. in Sec.

3 changed.

Pro-Link, Inc.

Canton, MA 02021

1-800-74-LINKS

Extra Duty Bowl Cleaner

Résumé du contenu

Page 1 - 1-800-74-LINKS

BRU MATERIAL SAFETY DATA SHEET N/A=Not Applicable Prepared by: Regulatory Affairs Dept. (Prepared According to 29 CFR 1910.1

Commentaires sur ces manuels

Pas de commentaire

Pro-link Extra Duty Bowl Cleaner B14097 Manuel d'utilisateur

Naviguer en ligne ou télécharger Manuel d'utilisateur pour Pour la maison Pro-link Extra Duty Bowl Cleaner B14097. Pro-Link Extra Duty Bowl Cleaner B14097 User Manual Manuel d'utilisatio

Résumé du contenu

Commentaires sur ces manuels

Produits connexes et manuels pour Pour la maison Pro-link Extra Duty Bowl Cleaner B14097